44. Lift BOP stack and replace wellhead connector AX ring. 吊起防喷器组并更换连接器AX密封圈
45. Function test wellhead. 对井口头进行功能试验
46. Fill kill and choke valves with seawater. 将压井阀和阻流阀注满海水 47. Pressure test to 500psi then bleed off test pressure. 试压到500psi, 然后放掉压力
48. Reduce hydraulic control manifold pressure to 5200 kpa. 将液压控制管线压力减少到5200千帕
49. Switch to alternate control pod. 把闸门开关倒到控制面板 50. Guidelines are slacked off. 导向绳松了
51. Slack off drill pipe and release running tool. 放松钻杆并卸开下入工具 52. Run subsea TV to observe bit entering the TGB. 下水电视观察钻头是否进入临时导向基板
53. Don’t rotate until hole opener passes through the TGB. 在扩眼器通过临时导向基板前不要旋转
54. Position permanent guide base (PGB) below rotary table. 在转盘下安放永久导向基板
55. Monitor riser level via trip tank. 用计量罐来控制隔水管内的液面 56. Pressure test to 5000psi. 试压5000psi
57. Pick up test mandril and place in BOP. 吊起试压防喷器芯子并装入防喷器组
Safety and Firefighting 安全与消防
16
328. Get a Work Permit before you can start the hot work. 办理作业许可证才能进行动火作业
329. Welding is not allowed. 不准动焊 330. Put on your (safety) helmet. 戴上安全帽 331. It’s a high voltage area. 这是高压区 332. That’s against the rule. 这是违章作业
333. Don’t walk under the crane load. 不要在吊物下走动 334. The repairing is under way. 正在检修
335. Keep your hands clear! (Keep you hands off! Do not touch!) 不要乱动 336. Wear and secure your safety belt. 戴上并系好安全带
337. Life jacket must be worn when working outboard or overhead. 舷外或高空作业要穿救生衣
338. Have your breathing apparatus near you. 保持放毒面具在附近 339. It’s a drill. 这是演习
340. It was a BOP drill. 这是防喷演习
341. Get in the lifeboat in order. 按顺序进入救生艇 342. Put on life jacket! 穿好救生衣 343. Abandon the vessel! 弃船
344. Sound the abandonment alarm! 发出弃船警报 345. Go to the helideck! 去飞机坪集合 346. Aboard the lifeboat. 登上救生艇
347. Aboard the supply boat to shore! 乘拖船上岸
348. Check life saving apparatus periodically. 定期检查救生设备
17
349. It’s for fire fighting. 这是消防用的 350. Start the fire pump. 启动消防泵 351. This rope is too small. 这根绳子太细了 352. It should be function tested. 需做功能测试 353. A warning notice should be set up. 要挂警告牌
354. Do you have an emergency program (contingency plan)? 你们有没有应急计划?
355. It must be ready in an emergency condition. 必须始终保持良好的应急状态
356. Will the typhoon hit our rig? 台风要袭击我们的平台吗? 357. We will have to evacuate the rig. 我们要撤离平台 358. Personnel on board (POB). 在船人员总数 359. Sound fire alarm. 发消防警报 360. This is a fire drill. 这是消防演习 361. conduct abandon ship drill. 举行弃船演习 362. Release the boat hooks. 释放救生艇吊钩 363. Board the life boat. 登救生艇
364. Remove the rust and paint with anti-corrosive primer. 除锈后上防锈底漆
365. Three rafts are located near life boat station port side. 在左舷救生艇站附近还存放有3个救生筏
366. Wear work vests when working below the cellar deck. 在圆井甲板面下面工作时须穿工作救生衣
18
367. The station bills need to be updated. 应急部署表须更新
368. Check the expiry date for all foam extinguisher. 检查所有泡沫灭火器的过期时间
369. Close all the water-tight doors. 关闭所有水密门
370. Safety procedure shall be followed at all the times. 在任何时候都应遵守安全程序
371. Anchor wires should have a Spelter type socket at anchor side. 抛锚绳靠锚的一端应使用锌压头
372. Colour code all the connection at the loading station. 在供给站管线接头处用颜色表明各管线
373. Verify that a high level alarm is installed on the sludge tank. 确认污水舱安装有高位警报
374. Don’t switch on during drilling operation. 钻井作业期间不能合闸 375. Provide two independent means to start the emergency generator engine. 应急发电机柴油机应有两套独立的起动方法
376. Have the boom pennant wires of port crane re-certified. 重新认证左舷吊车扒杆变幅绳
377. Clean the internals of the emergency switchboard. 清洁应急配电盘内部
Helicopter and Supply Vessel 直升机与供应船
378. Load out Contractor’s riser at Zhanjiang anchorage. 在湛江锚地把承包商的隔水管装上平台
379. Offload casing. (从供应船上)卸套管
19
380. Load (offload or unload) the boat. 装(卸)船
381. Get the food container loaded on the boat. 把食品集装箱装上船 382. The helicopter will land on rig soon. 直升机很快就要在平台降落 383. Tell the base to get (or send) a chopper here. 通知基地派飞机来 384. Helicopters are not allowed to land here. 飞机不能降落 385. Report the weather condition to the pilot. 向飞行员报天气 386. Inform the boat come to standby. 通知拖轮过来待命 387. Call the boat to come along port side. 通知拖轮过来靠左舷 388. We will take the personnel basket. 我们乘坐吊篮
Repair and Maintenance 检修
389. Have an overall check. 进行全面检查
390. MPI the brake linkage system. 对刹车连接系统进行磁粉探伤 391. Demonstrate that the make-up cathead can pull 7000 lbs. 证明上扣猫头能拉到7000磅
392. Determine the origin of the air leak and rectify this. 找出漏气的地方并处理
393. Adjust the brake band equalizer beam properly. 适当调整刹带平衡梁 394. Note that the 3000 hour inspection on TDS is due. 注意顶驱的3000小时保养时间已到
395. Check sheave rope pocket wear with a 1 3/8”+1 1/32 template. 用1 3/8”+1/32”量规检查绳槽磨损的情况
396. Repair the handrails on the crown. 修理天车台的栏杆
20