Lemmink?inen (China) Co., Ltd SE Tiger Project
莱木工程管理咨询（上海）有限公司 斯道拉恩索林纸一体化项目 Item 序号 Job steps 工作步骤 明治屋面板墙板 Construction requirement/method 施工要求及方法 珩架梁和水平支撑 Hazards 潜在风险 Level 风险等级 Controls Measures 控制措施 Responsible persons for work 指定负责人 ◆Hazard from roof truss P1 ◆Screw down the fixing bolt for truss beam on time when truss beam was 李建军 located on light steel column.当珩架梁就位后及时拧紧珩架梁的固定螺栓。 7.2 Workers stand on mobile beam overturn scaffold to install roof sandwich 屋面珩架梁倾覆风险 panel, wall sandwich panel and windows & doors 工人站在移动脚手架上安装三明治屋面墙面板和门窗。 ◆Hazard from power use, P1 electric tools operation and electric tools malfunction 用电、电动工具操作和电动工具故障风险 8 Hazard Install waterproof steel 8.1 Set up lifeline on roof during ◆sheet on sandwich truss beam installation 在珩架梁安装期间在屋面上安装生命线 8.2 Erect staircase access to roof with scaffold pipe 用脚手架钢管搭设上屋面楼梯式通道 sheet on roof 在屋面上安装0.5mm彩钢板 ◆Hazard from load P1 capacity of lifeline 生命线的荷载能力造installation 生命线安装风险 insulation layer of roof 在屋面的三明治保温层上安装防水彩钢板 from lifeline P2 Please see “Job Step 6” 李建军 ◆Lifeline pole already were welded on truss beam during truss beam 李建军 manufacture in factory, and worker stand on mobile scaffold to install lifeline before install sandwich roof panel.在珩架梁的工厂加工期间已经在珩架梁上焊接了生命线的立柱，并且在屋面三明治板安装前工人已站在移动脚手架上安装了生命线 ◆Set a Ф48*4mm steel pipe pole every 6m for lifeline. 每6m设置1根Ф48*4mm钢生命线立柱。 ◆Adopt Ф12mm steel wire rope as lifeline.采用直径12mm的钢丝绳作生命线。 ◆Adopt the special holder of steel wire rope to fix lifeline.用专用钢丝绳夹具固定生命线。 李建军 8.3 Install 0.5mm thick roof steel 成的风险 Safe Work Method Statement 安全施工方案
Page 16 of 18 Issue date Serial Number SWMS-JINHUA-002 Revision 1
Lemmink?inen (China) Co., Ltd SE Tiger Project
莱木工程管理咨询（上海）有限公司 斯道拉恩索林纸一体化项目 Item 序号 Job steps 工作步骤 Construction requirement/method 施工要求及方法 Hazards 潜在风险 Level 风险等级 Controls Measures 控制措施 Responsible persons for work 指定负责人 ◆Hazard from structure P1 collapse of scaffold access 脚手架通道结构垮塌风险 ◆Before start erection of scaffold access, access design must be submitted to 李建军 LMK safety department for approval, and may use the scaffold only after getting inspection and accepting of LMK’s department and hanging green card. 搭设脚手架通道前，必须提交通道的设计给LMK安全部门审核，并且仅在取得LMK安全部门的验收并挂绿牌后方可使用脚手架。 ◆Adopt Ф48X4 standard steel pipe and suitable standard fastener, the rusty, transmutative steel pipe and fastener or fastener with bad thread can never be used.采用Ф48X4标准钢管和配套的标准扣件，锈蚀、变形的钢管和扣件及螺纹损坏的扣件严禁使用。 ◆Hazard from people P2 falling during using scaffold access 使用脚手架通道期间人员坠落风险 ◆Harm to people from P2 materials drop during using scaffold access 使用脚手架通道期间落物伤人 ◆Hazard from people slip P3 during access 使用脚手架通道期间人员滑倒风险 using scaffold ◆Fully pave the 0.25m*0.05m wood board on landing and lean flight.在休息平台和斜跑上满铺0.25m*0.05m木板。 ◆Erect 0.6m high middle rail and 1.2m high top rail on landing and lean flight. 在休息平台和斜跑上设置0.6m高中护栏和1.2m高顶护栏。 ◆Prohibit to overstep or ride on rail.禁止翻越或骑坐在栏杆上。 ◆Install 150mm high washboards for landing and lean flight. 在休息平台和斜跑上安装150mm高踢脚板。 ◆Prohibit to pile materials on scaffold access during use.使用期间禁止在脚手架通道上堆放材料。 李建军 李建军 ◆Slope of lean flight is not more than 40 degree.斜跑的坡度不大于40度。 ◆Install a 15mm*50mm anti-slip strip every 300mm on wood board of lean flight.在斜跑板上每300mm安装15mm*50mm防滑条。 李建军 Safe Work Method Statement 安全施工方案
Page 17 of 18 Issue date Serial Number SWMS-JINHUA-002 Revision 1
Lemmink?inen (China) Co., Ltd SE Tiger Project
莱木工程管理咨询（上海）有限公司 斯道拉恩索林纸一体化项目 Item 序号 Job steps 工作步骤 Construction requirement/method 施工要求及方法 Hazards 潜在风险 Level 风险等级 滑鞋。 Controls Measures 控制措施 ◆Workers on roof must wear anti-slip shoes.在屋面工作的工人必须穿防◆Workers on roof must wear full-body harness with double lanyard, and at least 1 lanyard shall be hooked on the lifeline at any time during work.在屋面工作的工人应该穿有双绳勾的全身式安全带，并且在作业的任何时候至少一根绳勾勾在生命线上。 Responsible persons for work 指定负责人 李建军 ◆Fall hazard from roof P1 during install roof steel sheet 安装屋面彩钢板期间从屋面坠落风险
Safe Work Method Statement 安全施工方案
Page 18 of 18 Issue date Serial Number SWMS-JINHUA-002 Revision 1